Crystalyte X5303 MotorLighting
OwnerChristofer Parham
LocationAustell, Georgia United States map
Email email image
Vehicle S-750
This is a Tidal Force S-750 frame. It has all the Tidal Force guts removed and replaced with after market components.
MotorCrystalyte x5303 Brushless DC
This is a faster wind of this line of brushless DC motor.
Takes very low voltage to get very high speed. 44v will get you 40mph. Any voltage above that does create speed but it also create tons of torque.
Drivetrain21 Speed Shimano Shifting
Controller 18 FET Low RDS MOSFET Overclocker Ready LYEN Editi
Below is the specification:
Model: EC-184110-LYEN EDITION
Start immediate controller
Chipset: XCKJ8B116A
Circuit board version: EB218-A-3
18 x genuine IRFB 4110 MOSFET N-CH 100V (tested up to 110V before damage) 100V 1000uF Nichicon capacitors equipped
72V battery optimized (for higher or lower voltage & current such as 36V-100V, you may need to change the resistor network to avoid damage to the voltage regulator)
65A is the current rate (for higher current, you may need to beef up the trace, shunt, and reprogram it via the software)
Low voltage cut-off: 62.6v
Battery and motor phase wires gauge size: 12AWG
Dimension: 9" x 3.4" x 1.75"( 229mm x 87mm x 45mm) plus mount extensions
Total weight: 805 gram

Batteries12 Turnigy/Flightmax 30C, 22.20 Volt, Lithium-Polymer
24s3p 88v/15AH Turnigy/Flightmax 30C Lipo

450A Peak Discharge
1.5kwh of Power
System Voltage101 Volts
Charger 48v Meanwell Power Supply
48v Meanwell Power Supply. Its current limited to 10-11A. It has a voltage range from 16-58v.

I currently charge my 2 packs in parallel at 50.4v
HeaterN/A
Instrumentation2.11 Cycle Analyst
Top Speed52 MPH (83 KPH)
Im a bit heavy so acceleration numbers seems anemic. A rider half my size would cut the time by half. Also more amps would increase the acceleration and top speed.
AccelerationPersonal Results 325lb rider.
0-50% of Tops Speed 7.3 Seconds
50-100% of Top Speed 24 Seconds

Average 180lb rider.
0-50% of Tops Speed 4 Seconds
50-100% of Top Speed 13.2 Seconds

Values are obtained on level ground.

Range15 Miles (24 Kilometers)
325lb rider.
15 Miles At 45MPH+
40 Miles At 30MPH
66 Miles At 20MPH
88 Miles At 15MPH

Averager 180lb rider.
16 Miles At 45MPH+
46 Miles At 30MPH
81 Miles At 20MPH
111 Miles At 15MPH

Values are obtained on level ground.
Watt Hours/Mile95 Wh/Mile
180-325 lbs Rider
Worst Case High Speed Senario is 95 wh/mi at Top Speed 45+

Low Speed Senario is 17 wh/mi at 15mph
180lb Rider = 13.5 wh/mi

Low Speed While Pedaling is 9 wh/mi at 15mph
180lb Rider = 7 wh/mi

Values are obtained on level ground.
EV Miles
Current:1,274 Miles (2,049 Kilometers)
 
    As of 1/2/2011
Seating Capacity1 adult
Curb Weight70 Pounds (31 Kilograms)
Battery,Motor,Controller,Wires, Instruments,Bike
TiresBell Cruiser 26 x 1.95 Slicks
Conversion Time2 Months +

Always Upgrading
Conversion Cost$1750
Build Thread On Endless-Sphere
WebPage

code by jerry